Menu
- Vw Dsg Gearbox
- Vw Dsg Gearbox Problems
- Vw Dsg Gearbox Service
- Vw Dsg Transmission Fluid Change
- Vw Dsg Gearbox Lifespan
VW Passat (3C) | |
---|---|
Source: Thomas Doerfer | |
Information | |
Manufacturer: | Volkswagen AG |
Chassis Code: | 3C/AN |
Platform: | VW46X |
Model Years: | from 2006 |
Model Years (US): | from 2006 |
Predecessor: | VW Passat (3B) |
Successor: | None |
Interface Hardware | |
HEX-V2, HEX-NET, HEX+CAN, Micro-CAN | |
DLC Location | |
The DLC is located in the Driver Footwell. |
VW and Audi DSG Gearbox ECU problem (Mechatronic Control Module Fault) This is a very common problem for all Volkswagen and Audi vehicles fitted with the DSG (Mechatronic) 6-speed gearbox system. A1 Clutches have the highest skilled technicians for clutch & gearbox replacement, repair or installation. Call us to book your vehicle in for a free inspection at our Birmingham, Tipton, Cannock & Derby centre's today. VW had a lot of bad press back then around DSG and few other incidents, and increased the transmission warranty to 5 years. It may or may not apply to your specific vehicle though – depending on the exact year, and when they started and stopped the offer.
We have 'small' list of Common Modifications & Tweaks for the VW Golf/Jetta/Bora (1K/5M) that apply to the 2010 and older Passat.
We also have 'small' list of Common Modifications & Tweaks which apply to the VW Passat (3C/AN) MY 2011 only and VW Passat CC (35/AN) MY 2011 and up.
General Information about this Model can be found in the Wikipedia entry.
[01] - Engine Electronics
Gasoline Engines
- 1.6l MPI (BSE/BSF):
- 1.6l FSI (BLF):
- 2.0l FSI (BLR/BLX/BLY/BVX/BVY/BVZ):
- 2.0l TFSI (AXX/BGB/BPJ/BPY/BWA):
- Label File (06F-907-115-AXX.LBL)
- 3.2l FSI (AXZ):
- 3.6l FSI (BLV):
- Label File (03H-906-032-BLV.LBL)
Diesel Engines
- 1.9l TDI (BKC/BLS/BXE):
- 2.0l TDI (BKP/BMA/BMP/BMR/BVD/BVE/BUZ/BWV):
[02] - Transmission Electronics
- 6-Speed Direct Shift Gearbox (DSG/02E):
- Label File (02E-300-0xx.LBL)
- 6-Speed Automatic Transmission (09G):
- Label File (09G-927-750.LBL)
- 7-Speed Direct Shift Gearbox (DSG/0AM)
- Label File 0AM-300-04x.lbl
[03] - Brake Electronics
- Brake Electronics (< MY 2007)
- Label File (3C0-614-095-C2.LBL)
- Brake Electronics (MY 2008 >)
- Label File (3C0-614-109-C4.LBL)
[08] - Heating/Air Conditioning
- Climatic:
- Climatronic:
[09] - Central Electronics
- Central Electronics
- Label File (3C0-937-049-23-H.LBL - 17/21/23 Byte - Highline)
- Label File (3C0-937-049-23-M.LBL - 17/21/23 Byte - Midline)
- Label File (3C0-937-049-30-H.LBL - 30 Byte - Highline)
- Label File (3C0-937-049-30-M.LBL - 30 Byte - Midline)
- Subsystem: Wiper
- Subsystem: Rain/Light Sensor
[0F] - Radio (Digital)
- Sirius
- Label File (8E0-035-593-SIR.LBL)
- XM
- Label File (8E0-035-593-XM.LBL)
[13] - Distance Regulation
[15] - Airbag
- Label File (3C0-909-605.LBL)
[16] - Steering Wheel
[17] - Instrument Cluster
[18] - Auxiliary Heating
[19] - CAN-Gateway
- Label File (3C0-907-530.LBL)
[1C] - Position Sensing
[22] - All-Wheel-Drive
[25] - Immobilizer
This model uses Immobilizer Generation 4D which is integrated as part of the Comfort Control Module (J393).
- Replacement
- Label File (3C0-959-433-25.LBL)
[36] - Seat Adjustment (Driver)
- Label File (3C0-959-760.lbl Label File]
[37] - Navigation
- Navigation System (RNS-MFD2 CD)
- Label File (1T0-919-887.lbl Label File]
- Navigation System (RNS-MFD2 DVD)
- Label File (1K0-919-887.lbl Label File]
[3D] - Special Functions
[42] - Door Electronics Driver
[44] - Steering Assist
Note: The Steering Angle Sensor (G85) Calibration is done in address [03 - ABS Brakes]
[46] - Comfort System
- Label File (3C0-959-433-46.CLB)
[47] - Sound System
- Label File (3C0-035-456.lbl Label File]
[52] - Door Electronics Passenger
[53] - Parking Brake
![Codes Codes](/uploads/1/1/9/8/119877260/344254219.jpg)
If you are unsure which Generation is installed, check the Control Module Identification.
EPB stands for Generation II, EPB3 for Generation III and EPB4 for Generation IV.
EPB stands for Generation II, EPB3 for Generation III and EPB4 for Generation IV.
- Parking Brake (Generation II / < MY 2007)
- Label File (3C0-907-801-53.LBL)
Dealer parts departments may no longer carry the EPB3 modules because they have been superseded with the newer EPB4 modules. The Coding of the replacement modules will likely not be the same as the Coding in the old module but the Coding charts in VCDS should be applicable.
- Parking Brake (Generation III / MY 2008 - 2010)
- Label File (5N0-907-801.LBL)
- Parking Brake (Generation IV / MY 2011 >)
- Label File (3AA-907-801.LBL)
[55] - Headlight Aim Control
- Label File (5M0-907-357.LBL)
[56] - Radio (Analog)
- Radio Systems Generation 6 (R 100 und RCD 300/300+/500)
- Label File (1K0-035-1xx-56.LBL)
- Radio System (RNS-MFD2 CD)
- Label File (1T0-035-095.LBL)
- Radio System (RNS-MFD2 DVD)
- Label File (1K0-035-095.LBL)
![Dsg Dsg](https://cdn.goodao.net/gztranspeed/HTB1EsFmLVXXXXX3XXXXq6xXFXXXKTranspeed-7-speed-DQ200-oam-dsg-transmission.jpg)
[5D] - Operations
- Label File (3C0-035-151.LBL)
[62] - Door Electronics Rear Left
Vw Dsg Gearbox
[65] - Tire Pressure Monitoring
Vw Dsg Gearbox Problems
[69] - Trailer
[6C] - Back-Up Camera
- Label File (7L6-907-441.LBL)
[6D] - Trunk Electronics
[72] - Door Electronics Rear Right
[76] - Parking Aid
[77] - Telephone
- Telephone (Low)(PR-9W8)
- Telephone (Premium)(PR-9ZW)
[7D] - Auxiliary Heater
Retrieved from 'http://wiki.ross-tech.com/wiki/index.php?title=VW_Passat_(3C)&oldid=8259'
Vw Dsg Gearbox Service
The Midlands No. 1 Clutch Repair and Gearbox Installers
Vw Dsg Transmission Fluid Change
CORONAVIRUS UPDATE
Staying safe during #Lockdown3 - As an essential business all our branches will
remain open with continued safety measures in place
Established in 1990A1 Clutches are the leading Clutch and dual mass flywheel specialists in the Midlands, we operate from multiple state of the art sites, we specialise in all makes and models of cars, high performance cars, 4 – 4s, light commercial vehicles, motor homes and even horse boxes. We consistently strive to offer our customers an unbeatable service and provide a 2 year / 18,000 miles warranty on all clutches supplied and fitted by A1 Clutches, leading the way in our industry. A1 Clutches are a specialist IMI Approved Repairer of 7 speed DSG VW gearboxes.
All of our technicians are highly skilled in their field and are continually trained in the latest procedures and practices. We operate a reliable collection and delivery service and can supply you with a free courtesy car whilst your vehicle is being repaired subject to availability.
We offer a free no obligation check on your clutch while you wait by one of our highly skilled technicians, this only takes minutes so there is no need to book. Call in TODAY to any of our branches during opening hours or call us. Please note all our calls are recorded for training purposes.
Vw Dsg Gearbox Lifespan
Our opening hours are: Monday – Friday 8:00am – 5:30pm, Saturday 8:30am – 3:30pm